Blyuss B.A., Lukianov P.V., Dziuba S.V. Simulation of quasi-point turbulent vortex in the swirling flows of fluids in the preparation equipment

Details

Parent Category: Geo-Technical Mechanics, 2018

Category: Geo-Technical Mechanics, 2018, Issue 143

Geoteh. meh., 2018, 143, 49-59

https://doi.org/10.15407/geotm2018.143.049

SIMULATION OF QUASI-POINT TURBULENT VORTEX IN THE SWIRLING FLOWS OF FLUIDS IN THE PREPARATION EQUIPMENT

¹BlyussB.A.,²LukianovP.V., ¹DziubaS.V.

¹ Institute of Geotechnical Mechanics named byN. Polyakov of National Academy of Sciences of Ukraine, ² National Aviation University MSE of Ukraine

УДК [532.517.4:532.527:622.7.002.5].001.57

Languige: Ukrainian

Annotation.

In the article, the authors analyze parameters of operating efficiency of the hydrotechnical system modes used in technologies for mineral raw material processing, which determine a complex of functional, environmental and economic factors that objectively affect the production profitability and are realized through the creation of favourable conditions for modernization of the technologies, introduction of new tools and equipment and reduction of energy consumption in the processes of transportation. It is substantiated that for the preservation and renewal of mineral raw materials, the following basic conditions should be provided: rational use of mineral resources (especially for non-renewable resources); undertaking of effective measures for the natural resources renewing (to restore and improve natural fertility of the land, to bed forest plantations, to renew water reservoirs); maximization of the secondary raw materials and other waste products use; improvement and support of environmentally friendly processing industries and nature management. By using the concept of the Taylor-Coetta boundary current and its properties, a mathematical model of a quasi-point turbulent vortex is proposed. Since the parabolic law of longitudinal velocity for the laminar flow corresponds to a quasi-point laminar vortex, it is also logically to use a quasi-point vortex distribution for the turbulent flow. This very distribution corresponds qualitatively to the experimentally observed longitudinal velocity profile and, as a result, indicates the integral effect of reducing the turbulent viscosity based on the Reynolds equations and the Bussinesque gradient turbulence model. The main requirements for the rational use of mineral raw materials in Ukraine are the most complete extraction from the bowels and rational use of minerals and the components contained therein; prevention of harmful influence of mining works related to the use of mineral resources, on the mineral resources conservation; protection of minerals from flooding, fires and other factors that reduce their quality and value; and preservation and improvement of the environment in areas near the location of existing deposits.

Keywords:

mineral raw material, turbulent viscosity integral reduction, quasi-point turbulent vortex, optimum motion, stationary viscous rotational motion, hydraulic engineering systems

Referenses

1. Bulat A.F., Vitushko O.V., and Semenenko Ye.V. (2010), Modeli elementov gidrotehnicheskih sistem gornyih predpriyatiy [Models of elements of the hydrotechnical systems of mine enterprises], Gerda,  Dnepropetrovsk, UA.

2. Blyuss B.О., Dziuba S.V. and Semenenko Ye.V. (2018), «Ground parameters of efficiency of the hydrotechnical systems in technologies of processing of mineral raw material», Metalurgiynatagirnоrudnapromyislovist, no. 4, pp. 58-65

https://doi.org/10.33101/S04-58768473

3. Lukianov P.V. and Meshkov I.V. (2018),  «Helical flux structure and rate of fluid in curvilinear pipe with constant cross-section», Promyslova gidravlika i pnevmatyka, no. 2(60), pp 15—22.

4. Berdichevsky V.L. (1983), Variatsionnye printsipy mekhaniki sploshnoy sredy [Variational principles for mechanics of continuous medium], Nauka, Мoskow< SU.

5.  Flow and Transport Processes with Complex Obstructions: Applications to Cities, Vegetation Canopies, and Industry (Ye. A. Gayev and J.C.R. Hunt editors) (2006), NATO Science Series, Springer Publ., Vol. 236.

6. Kolisnichenko, A.V. (2014), «On inverse energy cascade in spiral turbulence of astrophysical non-magnetic disk», Preprints of Keldysh IPM, Vol. 70, 36 p. URLhttp://library.keldysh.ru/preprint.asp?id=2014--70.

7. Vysotsky L. I. (2013), «On existence of zones with negative turbulent viscosity in longitudinally homogeneous flows», Magazine of Civil Engineering, no. 2, pp. 48-53. https:// 10.5862/MCE.37.7

https://doi.org/10.5862/MCE.37.7

8. Loytsyansky L.G. (1987), Mekhanika zhidkosti i gaza [Mechanics of liquid and gas], Nauka,  Moscow, SU.

9. Schlihting  G. (1974), Teoriya pogranichnogo sloya [Boundary layer theory], Science, Moscow, SU.

10. Lukianov P.V. (2011), «Model of Quasi—Point Vortex», Research Bulletin of National Technical University of Ukraine  KPI, no. 4(78), P. 139—142.

11. Huisman S.G. , van Gils D.P.M. , Grossmann S., Sun C., and Lohse D. (2012), «Ultimate Turbulent Taylor Couetter Flow», Phys. Review letters, no.108(2), P. 024501.

https://doi.org/10.1103/PhysRevLett.108.024501

12. Townsend  A.A. (1956), The structure of turbulent shear flow,  Cambridge University Press, Cambridge, UK.

13.  Lukianov P.V. (2011), «Compact turbulent Vortex Generation Approximate Model for Relatively Large Time Moments». Research Bulletin of National Technical University of Ukraine  KPI, no. 4(90),  pp. 127—131.

14. Lukianov P.V. (2013), «Models of compact compensated vortex flows with helical symmetry»,  Applied hydromechanics, Vol.. 87, no.3, p p. 37—42.

About the authors

Blyuss Boryis Aleksandrovich, Doctor of Technical Sciences (D. Sc.) Professor, Head of Department of Geodynamic System and Vibration Tehnologies, M.S. Polyakov Institute of Geotechnical Mechanics National Academy of Sciences of Ukraine (IGTM, NAS of Ukraine), Dnipro, Ukraine, This email address is being protected from spambots. You need JavaScript enabled to view it.

Lukianov Pavel Vladimirovich, Candidate of Physics and Mathematics Sciences (Ph.D..), Senior Researcher, Accosiate Professor in  Hydro Gas Systems  Depertment, of National Aviation University MES of Ukraine, Kyiv, Ukraine, This email address is being protected from spambots. You need JavaScript enabled to view it.

Dziuba Serhii Vladimirovich, Candidate of Technical Sciences (Ph.D), Senior Researcher in Department of Geodynamic System and Vibration Tehnologies, M.S. Polyakov Institute of Geotechnical Mechanics National Academy of Sciences of Ukraine (IGTM, NAS of Ukraine), Dnipro, Ukraine, This email address is being protected from spambots. You need JavaScript enabled to view it.

• < Prev
• Next >